PHILLIPS PETROLEUM CO, PHILLIPS 66 CO DIV -- GASOLINES (ALL GRADES)  -- 9130-01-135-2507
<pre>=====================  Product Identification  =====================

Product ID:GASOLINES (ALL GRADES)
MSDS Date:03/31/1990
FSC:9130
NIIN:01-135-2507
=== Responsible Party ===
Company Name:PHILLIPS PETROLEUM CO, PHILLIPS 66 CO DIV
Address:699 ADAMS BLDG
City:BARTLESVILLE
State:OK
ZIP:74004
Country:US
Info Phone Num:918-661-8327, 918-661-5952
Emergency Phone Num:918-661-3865, 918-661-8118
CAGE:46916
=== Contractor Identification ===
Company Name:PHILLIPS 66 COMPANY(DIVISION OF PHILLIPS PETROLEUM CO)
Address:699 ADAMS BLDG 411 KEELER ST
Box:City:BARTLESVILLE
State:OK
ZIP:74004
Country:US
Phone:918-661-8327
CAGE:6Y142
Company Name:PHILLIPS PETROLEUM CO
Address:613 ADAMS
Box:City:BARTLESVILLE
State:OK
ZIP:74004
Country:US
Phone:800-234-6603
CAGE:46935
Company Name:PHILLIPS PETROLEUM COMPANY
CAGE:46916

=============  Composition/Information on Ingredients  =============

Ingred Name:GASOLINE.  THE INGEDIENTS FOLLOWING MAKE-UP THE GASOLINE.
CAS:8006-61-9
RTECS #:LX3300000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:300 PPM/500 STEL
ACGIH TLV:300 PPM/500STEL,9293

Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS

Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:P-XYLENE (P-DIMETHYLBENZENE) (SARA III)
CAS:106-42-3
RTECS #:ZE2625000
Fraction by Wt: <3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:M-XYLENE (M-DIMETHYLBENZENE) (SARA III)
CAS:108-38-3
RTECS #:ZE2275000
Fraction by Wt: <6%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/15OSTEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:O-XYLENE (O-DIMETHYLBENZENE) (SARA III)
CAS:95-47-6
RTECS #:ZE2450000
Fraction by Wt: <3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:METHYL-TERT-BUTYL ETHER (SARA III)
CAS:1634-04-4
RTECS #:KN5250000
Fraction by Wt: <15%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB

Ingred Name:1,2,4-TRIMETHYL BENZENE (SARA III)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: <3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9293

Ingred Name:TETRAETHYL LEAD (SARA III) (< 0.25 G/GAL, EQUIVALENT TO
    <0.1 G PB/GAL FOR LEADED GASOLINE; <0.05 G PB/GAL FOR UNLEADED.
CAS:78-00-2
RTECS #:TP4550000
Fraction by Wt: <.25%G/G
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, 0.075 MG PB/M3
ACGIH TLV:S, 0.1 MG PB/M3 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:LD50 ORAL RAT IS UNKNOWN.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:NO
Reports of Carcinogenicity:NTP:YES    IARC:YES	  OSHA:YES
Health Hazards Acute and Chronic:EYES: MAY CAUSE SLIGHT IRRITATION.
    SKIN: SLIGHT IRRITATION. INHALATION: MAY CAUSE HEADACHE, NAUSEA,
    WEAKNESS, SEDATION, AND UNCONSCIOUSNESS. INGESTION: MAY CAUSE
    IRRITATION TO INTESTINES. MAY BE ASPIR ATED INTO LUNGS IF
    SWALLOWED, WHICH MAYRESULT IN PULMONARY EDEMA AND CHEMICAL
    PNEUMONITIS.
Explanation of Carcinogenicity:CONTAINS B	[71-43-2] WHICH IS
    LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION. INHALATION:
    HEADACHE, NAUSEA, WEAKNESS, SEDATION, AND UNCONSCIOUSNESS.
    INGESTION: IRRITATION TO INTESTINES. ASPIRATION INTO LUNG AFTER
    INGESTION MAY RESULT IN PULMO NARY EDEMA AND CHEMICAL PNEUMONITIS.
Medical Cond Aggravated by Exposure:PERSON WITH PRE-EXISTING DISEASE
    INVOLVING THE EYES, SKIN OR RESPIRATORY TRACT MAY BE AT INCREASED
    RISK FROM EXPOSURE TO THIS PRODUCT.

=======================  First Aid Measures  =======================

First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. IF IRRITATION
    DEVELOPS GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
    WASH AREA WITH SOAP AND WATER. IF IRRITATION DEVELOPS GET MEDICAL
    ATTENTION.	INHALATION: MOVE TO FRESH AIR. IF NOT BREATHING GIVE
    CPR. IF BREATHING DIFFICULT GIVE OXYGEN. GET MEDICAL ATTENTION.
    INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION.

=====================  Fire Fighting Measures  =====================

Flash Point:<-37.2C, -35.F
Lower Limits:1.5
Upper Limits:7.6
Extinguishing Media:DRY CHEMICALS, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:DO NOT SPRAY WATER DIRECTLY ON FIRE, PRODUCT
    WILL FLOAT AND REIGNITE ON WATER SURFACE. WATER FOG OR SPRAY MAY BE
    USED TO COOL EXPOSED CONTAINERS AND EQUIPMENT.
Unusual Fire/Explosion Hazard:HIGHLY FLAMMABLE VAPORS WHICH ARE HEAVIER
    THAN AIR MAY ACCUMULATE IN LOW AREAS AND SPREAD ALONG GROUND TO
    DISTANT IGNITION SOURCE AND FLASHBACK.

==================  Accidental Release Measures  ==================

Spill Release Procedures:SHUT OFF SOURCE IF POSSIBLE. VENTILATE AREA.
    PROTECT FROM IGNITION. DIKE AREA TO CONTAIN SPILL. KEEP OUT OF
    WATER SOURCES AND SEWERS.. ABSORB IN DRY, INERT MATERIAL. TRANSFER
    TO DISPOSAL CONTAINERS US ING NON-SPARKING TOOLS. WEAR
    PROTECTIVEEQUIPMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
    AREA AWAY FROM HEAT, IGNITION SOURCES, INCOMPATIBLE MATERIALS. KEEP
    CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:PROTECT CONTAINERS FROM PHYSICAL DAMAGE. BOND AND
    GROUND CONTAINERS DURING TRANSFER. DO NOT SIPHON BY MOUTH. PROVIDE
    MEANS OF CONTROLLING LEAKS AND SPILLS. AVOID CONTACT WITH EYES AND
    AVOID BREATHING  VAPORS.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:USE NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR
    FOR CONCENTRATIONS EXCEEDING THE RECOMMENDED EXPOSURE LEVEL. WHEN
    ENTRY INTO CONCENTRATIONS OF UNKNOWN EXPOSURE, USE NIOSH/MSHA
    APPROVED SELF-CONTAINED  BREATHING APPARATUS (SCBA).
Ventilation:USE ADEQUATE VENTILATION TO CONTROL EXPOSURE BELOW
    RECOMMENDED LEVELS. USE EXPLOSION-PROOF EQUIPMENT.
Protective Gloves:VITON, NITRILE, PVA.
Eye Protection:SAFETY GLASSES WITH SIDE SHIELDS.
Other Protective Equipment:FULL BODY LONG-SLEEVED GARMENTS TO PREVENT
    REPEATED OR PROLONGED SKIN CONTACT. EYE WASH STATION AND SAFETY
    SHOWER.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
    DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE..
Supplemental Safety and Health
PERSONAL PROTECTION INFORMATION SHOWN ABOVE IS BASED UPON GENERAL
    INFORMATION AS TO NORMAL USES AND CONDITIONS. WHERE SPECIAL OR
    UNUSUAL CONDITIONS EXIST, IT IS SUGGESTED THAT THE EXPERT
    ASSISTANCE OF  AN INDUSTRIAL HYGIENIST OR OTHER QUALIFIED
    PROFESSIONAL BE SOUGHT.

==================  Physical/Chemical Properties  ==================

HCC:F1
Boiling Pt:=26.7C, 80.F
Vapor Pres:350-800
Vapor Density:3-4
Spec Gravity:0.8
Evaporation Rate &amp; Reference:>1 (BUTYL ACETATE = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED-ORANGE LIQUID. PUNGENT ODOR.
Percent Volatiles by Volume:100

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
OXYGEN AND STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
    OF IGNITION.
Hazardous Decomposition Products:CARBON OXIDES, LEAD FUMES (FOR GRADES
    CONTAINING TETRAETHYL LEAD), AND VARIOUS HYDROCARBONS WHEN BURNED.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

====================  Disposal Considerations  ====================

Waste Disposal Methods:CONSULT YOUR LOCAL ENVIRONMENTAL OFFICER.
    DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
    REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.